content top

Tips for Restoring Your Car’s Finish

3 Ways To Prepare For Painting Your Car

Posted by on Apr 13, 2016 in Uncategorized | Comments Off on 3 Ways To Prepare For Painting Your Car

In an effort to save money, many car owners are turning to do-it-yourself solutions for repairing and restoring their cars. Part of the DIY movement is painting your own car. If you are planning to paint your own car, here are some preparation tips to keep in mind to get the best results.  Remove the Rust Rust can ruin a good paint job before it even starts to dry. The rust can lead to unsightly bubbles in the paint that are difficult to mask. It is because of this, you need to remove the rust before starting.  There are a couple of ways you can deal with the rust. If the rust is slight, you can use a rust conversion kit. The kits work by changing the rust to iron phosphate, which you can paint over. Once the area dries, you can safely apply paint and the appearance of the car is not impacted.  If you know how to weld, you have the option of removing the area which is rusted and replacing it with another sheet of metal. If you are faced with severe rust that has eaten through the surface of the metal, this is the best option.  Take Off the Trim When painting your car, you have to be careful to tape all of the trim and other components that you do not want painted. Unfortunately, it can take additional time and effort to expertly avoid getting paint on those area, even with the tape secured.  An easy way to avoid painting the trim is to simply remove it. Make note of where each part came from as you remove it. Once the paint dries, you can replace the trim without fear of messing up the paint job.  Setup the Paint Area Painting a car can be a messy affair. It can also be a dangerous one if you are not doing it in a well-ventilated area.  Your painting area should be well-ventilated and out of direct sunlight. The sunlight can lead to dry spots in your finished product. If possible, try to paint in an area that is not too dusty. You can even lay down a tarp over the ground to keep the dust down around the car.  There are many other preparatory steps you can take before painting your car. Review the directions with the auto paint kit and follow them as closely as possible to achieve a good paint job. For more information, contact a company like Space Age Auto Paint...

read more

Three Reasons Your Forklift Battery Has Failed

Posted by on Feb 5, 2016 in Uncategorized | Comments Off on Three Reasons Your Forklift Battery Has Failed

Whether you use your forklift in a warehouse or around a construction site, it undoubtedly plays a critical role in overall production. When you fail to care for the forklift battery correctly, this can completely immobilize the machine and leave you in a panic. Make sure you know what factors can contribute to a battery failure so that you can avoid them. Inaccurate Hydrometer Levels When charging a forklift battery, a normal part of this process includes checking the hydrometer reading. All battery manufacturers have a suggested range in which this reading should occur. Even if your battery isn’t showing any noticeable signs of failure, an inaccurate meter reading is an indication that the electrolyte solution that helps power the battery, isn’t performing correctly. In many instances, this is a prelude to battery failure that could occur in a short period of time or not for quite a while. This unpredictability is what makes this problem so critical. Should you notice an inaccurate reading, have the battery serviced promptly. Failure To Water One of the factors that makes forklift batteries unique is the fact that they require watering, a process where water is inserted into the battery chamber to moisten the cells. This process should occur each time the battery has been completely charged and has had time to cool off. When this watering practice doesn’t occur regularly, this can cause the cells to dry out. Dried out battery cells will result in permanent damage to the cells, but more importantly, it can cause permanent damage to the entire battery. If your battery has abruptly stopped working, this could be the cause. Discharging Too Low Another thing can cause damage to your forklift battery is improper discharge. Most batteries will have a preset discharge level at which you need to recharge the battery. If you ignore this and allow the battery to deplete lower than this level, you can cause damage. Follow this practice regularly and you can minimize the efficiency level at which the battery can hold its charge and you can also shorten the overall life of the battery. In some cases, it can also cause the battery to overheat, which won’t only cause battery failure, but it can also cause damage to nearby components like the motor. If your battery is failing, a heavy equipment repair specialist such as Florida TRUCK & Trailer CO can diagnose the malfunction and repair the problem so that you can get your forklift moving...

read more

The Dos And Don’ts Of Cleaning A Vinyl Wrapped Vehicle

Posted by on Dec 17, 2015 in Uncategorized | Comments Off on The Dos And Don’ts Of Cleaning A Vinyl Wrapped Vehicle

Vinyl wrapping is a great way to market and advertise your business or even show your love for your favorite sports team. However, this is only the case if your wrap looks great. Knowing the dos and don’ts of washing a vinyl wrapped vehicle is a great way to ensure your wrap looks its best. Thoroughly Dry Your Vehicle Make it a point to thoroughly dry your vehicle after exposure to moisture. The problem with this is that water, from the tap or the rain, often has some trace of minerals, such as iron or calcium. With a vinyl wrapped vehicle, prolonged exposure to these minerals can cause the adhesive used to bond the vinyl to weaken. This can lead to air bubbles along the surface. This can also wear down your clear coat, which can expose the vinyl wrap to damage. Make it a point to thoroughly dry your vehicle whenever it gets wet. For the best result, use a microfiber cloth because of its greater water absorbing qualities and softer texture. Don’t take your vehicle through a high-powered air blower. Choose Wash Products Carefully Cleaning your vinyl wrapped vehicle is best accomplished with a mixture of water and mild detergent. However, it’s still important to proceed with caution as some vehicle cleaners can be damaging to the vinyl. Even if you do find a cleaner that states it’s safe for use on vinyl, it’s still important to test the cleaner before applying it all over. Find a small, inconspicuous place to apply the cleaner and wait a few days to see if it produces a negative effect. You also want to avoid using a polish or wax over the vinyl as the chemicals inside these products can cause the vinyl to deteriorate. Regulate Water Pressure For the most part, it’s best to avoid automatic car washes. Automatic car washes are often equipped with high-pressure water hoses that can damage the adhesive under the vinyl and cause air bubbles and peeling along the wrap surface. Washing centers that offer hand washing are generally safer. If you plan to wash your wrapped vehicle on your own, make sure the water pressure is below 1200 psi for the best results. As an added tip, if you fail to regulate water pressure and your wrap sustains damage, your warranty could be voided. The more effort you put into washing your vinyl wrapped vehicle correctly, the longer the vinyl lasts and, more importantly, the better it will look. For more tips, contact companies like Kwik...

read more

How To Fix Minor Scratches On A Car

Posted by on Sep 30, 2015 in Uncategorized | Comments Off on How To Fix Minor Scratches On A Car

A scratch on the side of the car can look unattractive and draw the attention to it. Over time if not dealt with properly a scratch can eventually turn into a rust spot and continue to spread throughout the rest of the body of the car. Fixing a minor scratch on your car is relatively easy and can be done at home with simple rubbing compound, rags, and soap and water. Here is a list of step-by step instructions on how to fix minor car scratches. To complete this task you will need the following items: A bottle of rubbing compound A bucket Warm water Dish soap Soft cloths that can be used as rags A scratch proof cloth that you can use to polish the vehicle 1 – Start by cleaning the area with the scratch with soap and water. Fill a bucket with warm water and add a couple squirts of dish soap. Then, mix the two together. Dunk the sponge into the water, and then apply it to the scratched area. Make sure you get inside the scratch to get out the dirt and contaminants that could cause a potential problem. Then dry the area with a soft rag to get rid of all the excess water. 2 – With a cleared area, take a bottle of rubbing compound and apply a small portion to another soft rag. Take with rag with the compound, and in a circular motion, apply it over the scratch using pressure to smooth out the visible signs of the scratch. Rub all over the scratched area with the rag, and reapply the rubbing compound to the rag as needed. 3 – Let the rubbing compound dry for a full 24 hour period, and then reapply more if needed. You should begin to see a noticeable difference in the look of the scratch and see signs of improvement in how visible it appears on the vehicle. 4 – Take a scratch proof cloth and polish the area of the car to complete the job. If you have followed the tips above and the scratch is still extremely visible on the vehicle it could be a much larger scratch that needs to be fixed by an auto body expert, like those at Bowling Green Lincoln Auto Sales. An auto body expert can take apart parts of the car and repair the scratches with auto body...

read more

RV Body Damage after a Collision: Why You Should Get the Windshield Fixed

Posted by on Jun 24, 2015 in Uncategorized | Comments Off on RV Body Damage after a Collision: Why You Should Get the Windshield Fixed

Did you get into a collision that left the body of your RV damaged? You may want to take your RV to an auto body repair shop as soon as possible, especially if your windshield was damaged in the collision. Find out below why a prompt auto body repair is in your best interest and what a mechanic might charge to help. Is it Dangerous to Drive an RV with Body Damage from a Collision? Driving an RV that has a lot of dents in it from a collision is not dangerous. However, dents can make it hard for the doors and trunk to open, so getting them removed is in your best interest. The most dangerous aspect of driving an RV that has been in a collision is not getting a broken windshield repaired. The windshield is the most important part of an auto body because it is in place for more than simply keeping rain and objects out. You must understand that a windshield can be helpful in the event that you get into another collision when it comes to your safety. The windshield must be in a good condition because it can decrease the amount of impact that you feel in a collision by sending most of the force into the chassis. You will feel a lot of the impact inside of the RV if the windshield is cracked. You will also have more protection in a rollover accident if you get the cracked windshield in your RV repaired. The windshield can prevent the hood of your RV from getting completely crushed in a rollover collision. If the cracks in your windshield are long and deep, you will be better off with getting it replaced with new glass than simply getting the cracks fixed. What Does It Cost to Get the Windshield Replaced in an RV? The make and model of your RV will play a role in how much an auto body specialist will charge to replace the windshield. It costs $100 plus on average to replace a windshield. However, you can end up paying $500 plus if you have a windshield that is rare and hard to replace. Paying for a new windshield is worth the investment no matter how much money you have to pay, as it is for your own safety. Call an auto shop like Central Body Co Inc to get your RV body repaired as soon as...

read more

Car Restoration: Tips On Picking The Right Vehicle

Posted by on Jun 18, 2015 in Uncategorized | Comments Off on Car Restoration: Tips On Picking The Right Vehicle

If you have decided to look for a classic car to restore as a hobby, you may wonder if you are getting a good deal or not when it comes time to make the sales transaction. Since classic cars are several decades old, finding one will most likely be done through a private seller. You will need to be diligent on inspecting vehicles for any signs of wear that may hinder you from a successful restoration. Here are a few tips to use when searching for the perfect classic car restoration project: Look For Value Retention Do your homework before going out to buy a car to restore. Opt for a vehicle that will be considered valuable after you fix it up. The vehicle may cost a little more initially, but after it has been repaired and painted it will bring in substantially more money should you decide to sell it down the road. Make Sure Parts Exist While rare vehicles are valuable after restored, you need to be sure the parts will be available to get them back to pristine condition. If there is a parts shortage on a particular model you may need to abort your restoration project completely. If you do find parts you need, they may be extremely costly.  Check The Engine Pick a vehicle that runs. Purchasing a vehicle that has been sitting around in non-running condition is risky as you will have no idea what problems could be causing it not to start. You may luck out and only need to replace a battery or starter, or you may be searching for an entire engine. Rather than take that chance, decide on a vehicle you are sure will be roadworthy without doing detective work. Look For Rust Do not buy a vehicle that has excessive rusting unless you are prepared to do the work involved in replacing complete panels of metal. This will include sand blasting and welding and will consist of a lot of extra work to get the vehicle back to its original condition. Look underneath the vehicle for any worn portions that may be a hazard to the frame.  Enlist Some Help Ask a friend to come along with you when you inspect a vehicle as a restoration prospect. Having someone knowledgeable in mechanics and auto body work will be a big plus when it comes time to make a price offer. Ask your regular mechanic if they know of an expert in the field that would be willing to take a look at potential vehicles with you. Many classic car enthusiasts will be happy to help a new person get started. To learn more, contact a company like Ray Donch Body Werks...

read more

2 Vehicle Repairs To Perform Before Leaving On A Road Trip

Posted by on Jun 3, 2015 in Uncategorized | Comments Off on 2 Vehicle Repairs To Perform Before Leaving On A Road Trip

Road trips are very entertaining vacations, but there are a few things that you should do to prepare your vehicle for the upcoming drive. Having your tires and windshield replaced are two great ways to get the most out of your vehicle on your next trip. Tires Replacing your tires is often a very good idea prior to a road trip so that you can ensure that you have sufficient tread on the tires. The main reason for this is that having insufficient tread on your tires increases the probability of one of your tires going flat or blowing out, which can leave you stranded in the middle of nowhere. When the tread on your tires has reached 1/16 of an inch, they will no longer be safe to drive on. You can easily measure your tread depth by simply using a penny. Place the penny upside down in the tread at the the point where the tread is the deepest. If you can see the Lincoln’s head on the penny at all, you should start considering new tires. If you can see the entirety of Lincoln’s head or beyond, then the tires are worn down to the point where it is actually dangerous to drive on them. Another reason to replace your tires is that tires with worn down treads can be harder to control because they cannot grip the road as well as new tires. This can lead to you not having enough control over your car to avoid road hazards, which can result in you getting into an accident. Fuel economy is also an important reason to replace your tires. If your tires are not gripping the road very well due to low tread depth, then your engine will have to work harder to spin the tires sufficiently to keep your car moving forward. The harder the engine works, the more money you will have to spend on fuel throughout your road trip. Windshield Replacing your windshield is very important before leaving on a road trip if it is badly cracked or if there are multiple chips in it. Large cracks in the windshield can result in obstructed vision, which means that you may not notice an obstacle in the road until it is too late to avoid it. In addition, a cracked windshield is not as able to protect you in the event of an accident. This is because the cracks weaken the windshield, particularly if you are involved in a rollover accident. In that situation, the windshield is not able to provide enough strength to your car’s roof due to the cracks, which can lead to the windshield shattering and the roof caving in on you and your passengers. Speak to an auto repair shop or mechanic today in order to discuss the various preparations that you should make prior to leaving on your trip. Replacing your windshield and tires will make the vehicle quite a bit safer while on a road trip. Replacement tires are also a good way to lower your fuel costs so that you can have a bit more money to spend on your trip. Contact a shop like Convoy Collision and Auto Body to get...

read more

2 Things You Need To Know About Taking Your Car To An Auto Body Shop

Posted by on May 26, 2015 in Uncategorized | Comments Off on 2 Things You Need To Know About Taking Your Car To An Auto Body Shop

For many people, their car is one of the biggest expenses. They pay a good deal of money on the car alone, and then they must pay for insurance and maintenance. This is why it is so important that you take the time to properly care for your car. If you have been in some sort of accident you might need an auto body shop to do the cosmetic work. Here are some things you need to know about using an auto body repair shop. 1. Be Realistic About The Time It is important that you are realistic about the amount of time that it will take to repair the car. Depending on the severity of the work, the auto body shop will need to order in parts before they fix it. Most shops do not have all of the parts for your car lying around the shop. They will need to assess the damage and then order the parts for your specific, make, model, year and color of car. Second, even if they have all of the parts they might do one part of the repair, and then wait for that part to dry or seal before they can work on more. Thus, this is not an in and out thing. In many cases it will take a good deal of time to repair your car. 2. You Should Also Take It To A Mechanic Some auto body shops are able to do both the mechanical and the physical repairs on the car, but in most cases you will need to find a mechanic to look at the car and an auto body shop to repair the physical part of the car. You should consider taking the car into the mechanic before and after the auto body repairs. This is because there might be something mechanically wrong with a car, especially if you were recently in a car accident that caused the car to need serious mechanical maintenance. It would be best to get that done before you go through all the effort to make the car look perfect. Then you will need to take the car into the mechanic afterwards to make sure that during the process of fixing the body, that nothing was moved. Even the best auto body shops make mistakes, and need you to make sure that the car can pass safety and emissions and is safe to drive. By doing these things you can get the best out of your experience with an auto body...

read more

3 Reasons To Have Your Car Professionally Painted

Posted by on May 22, 2015 in Uncategorized | Comments Off on 3 Reasons To Have Your Car Professionally Painted

Is your car in desperate need of a paint job? If so, then you have probably considered doing some of the work yourself to save money. However, you should know that attempting to do your own repairs isn’t always the best idea. There are many aspects to painting a car that you may not be able to do at home, and if you try to do so, the paint may look uneven or may not even match the rest of your car. Therefore, it is always better to have a professional do the work for you. Here are three very important reasons why you should always get a professional to paint your car: 1. Matching Paint Colors is Difficult If you order car paint online, even when you use the car’s specified paint colors that are listed in the owner’s manual or in the various locations on the car, that doesn’t automatically guarantee that the paint will look the way it is supposed to. On the other hand, if you take it to a professional paint shop, you can rest assured that everything will most likely look the way it’s supposed to, because they have technology that will allow them to mix paint properly, take exact matches of your paint color, and more. 2. They Can Get Out Blemishes Easier If there are any blemishes in your car that you will need to take care of before painting it, chances are that you won’t be able to get them all out when trying to do the work on your own. However, a professional painter should generally be able to get rid of these blemishes by buffing them out or by employing another technology to ensure that your car looks like new after the paint is applied to it. 3. You Don’t Want Your Paint to Look Splotchy Doing paint work on your own can cause your car to have paint splotches all over the place, especially when you don’t take the necessary protective measures to keep the paint from dripping onto other areas of the car. It will also be blatantly obvious that the car has been painted because of the way the paint will stand out from the rest of the professional paint. Therefore, if you want your car to be nice and shiny and have a good clear coat over it, you may want to consider taking it to the professional paint shop. Don’t take chances. Consider leaving the tough work to the professionals by taking your car to a paint shop like Franks Auto Body Inc....

read more

How To Protect Your Car’s Paint From Sun And Heat Damage This Summer

Posted by on May 19, 2015 in Uncategorized | Comments Off on How To Protect Your Car’s Paint From Sun And Heat Damage This Summer

As the summer sunshine settles in and prepares for another warm season, it’s time for you to start preparing your car. After all, when your car’s paint is exposed to the sun and heat all summer, it puts the paint finish at risk of wear. Not only do the sun’s ultraviolet rays cause fading and other damage to paint, but the heat can actually bake dirt and bug debris into your car’s paint, making it nearly impossible to get rid of. Here are some tips to help you keep your car’s paint safe from these hazards and looking its best all summer long. Keep it Covered Whenever possible, park your car in a covered space such as a carport or a garage. This will not only help keep the paint finish cooler, but it protects it from UV damage as well. The more frequently you can park your car under cover, the less risk you’ll have of color fading. Wash it Often In order to reduce the chances of dirt and debris baking into your paint finish, you’ll want to wash your car frequently throughout the summer. The frequency of washing will depend on how often you use the car, but at least once every couple of weeks is a good place to start. After all, the longer you leave dirt on the car, the greater the chances are that it will penetrate your car’s paint finish. If you want to scrub it yourself, you can even make a wash solution of your own. Use a gentle dish detergent that’s good at cutting grease and grime, and mix about a tablespoon of detergent in a couple of gallons of warm water. Dry it Yourself Once you wash the car, it’s tempting to just let it bake in the sun to dry. Water spots may actually cause mineral deposits that can damage the paint, so it’s best to avoid the air-dry process. Instead, invest in a few quality soft towels and dry the car by hand. Cotton towels are absorbent and soft, making them a great option for this. Wax it Frequently Invest in a car wax that includes ultraviolet ray protection, and apply it a couple of times throughout the summer. If you notice the wax finish starting to fade, make a point of reapplying a new coat of wax after the next wash. The wax will not only protect the paint from the sun, but it may also help keep bugs and dirt from reaching the paint. With these care tips, you can keep your car’s finish looking great throughout the summer. If necessary, you can even work with an auto body shop, like Auto Body By Duie LLC, to detail and prepare your car before the temperatures start to...

read more